Now when paving the asphalt road, the asphalt spreader has become an indispensable part of the construction technology, but the asphalt is a kind of liquid that is easy to solidify, and can only maintain normal circulation in high temperature. Therefore, every time we use up the car, we must effectively clean the asphalt tank, so as to avoid the blockage caused by the solidification of residual asphalt in the tank and pipeline So cleaning the tank is a very important step. Let's talk about the methods (intelligent asphalt cement spreader) when cleaning the tank and what we should pay attention to.

柴油通常用于清潔瀝青罐。 如果具有一定的厚度，則可以先通過物理方法將其清洗，然后再用柴油清洗。 當洞穴抽底油時，將激活通風系統，以確保工作場所的通風。 清潔罐底污垢時容易發生油氣中毒事故，必須采取保護措施以防止中毒。 另外，檢查通風設備的技術狀態，并啟動風扇通風。 洞穴和半地下瀝青罐中的瀝青罐應連續通風。 停止通風后，必須密封瀝青罐的上部開口。 檢查人員的防護服和呼吸器是否符合安全要求； 檢查所使用的工具和設備木材是否符合防爆要求，然后進入瀝青罐以清除污垢。

Diesel oil is usually used to clean asphalt tanks. If it has a certain thickness, it can be cleaned by physical method first, and then cleaned by diesel oil. When the bottom oil is pumped from the cave, the ventilation system will be activated to ensure the ventilation of the workplace. When cleaning the dirt on the bottom of the tank, it is easy to cause oil and gas poisoning, so protective measures must be taken to prevent poisoning. In addition, check the technical status of the ventilation equipment, and start the fan ventilation. Asphalt tanks in caves and semi underground asphalt tanks shall be continuously ventilated. After the ventilation is stopped, the upper opening of the asphalt tank must be sealed. Check whether the protective clothing and respirator of personnel meet the safety requirements; check whether the tools and equipment used meet the explosion-proof requirements, and then enter the asphalt tank to remove the dirt.
            

另外，在瀝青罐的使用過程中，突然發生電源故障或循環系統故障，除了通風和冷卻外，我們別忘了更換冷傳熱油，并且更換必須快速有序。 提醒您的不是說冷油更換閥太開。 在更換過程中，我們的油閥的開度從大到小都遵循規則。 這是為了盡可能延長更換時間，同時確保有足夠的冷油進行更換，從而有效避免瀝青加熱箱處于無油或低油狀態。

In addition, in the process of using the asphalt tank, if there is a sudden power failure or circulation system failure, in addition to ventilation and cooling, we should not forget to replace the cold and heat transfer oil, and the replacement must be fast and orderly. It's not that the cold oil change valve is too open. In the process of replacement, the opening of our oil valve follows the rules from large to small. This is to prolong the replacement time as much as possible, and ensure that there is enough cold oil for replacement, so as to effectively avoid the asphalt heating tank in the state of no oil or low oil.

瀝青水泥撒布車在長期使用過程中，不可避免地會因頻繁使用而磨損設備。 為了確保設備的正常使用，我們應定期維護和保養。

In the long-term use of asphalt concrete spreader, it is inevitable that the equipment will be worn due to frequent use. In order to ensure the normal use of the equipment, we should maintain it regularly.